Biological starter fermentation silage
Product introduction
Fuld Microbial Fermenter is a new type of pure green biological product researched and developed using Japanese biotechnology and can be used for the fermentation of silage. It contains a variety of complex micro-organisms with special functions and beneficial symbiosis, mutual antagonism and mutual cooperation. Under certain suitable conditions, microorganisms (mainly lactic acid bacteria in the silage) can rapidly grow in geometric progression, thereby completing the silage fermentation process. Appropriate fermentation materials: corn stalks, potato vines, peanut vines, grass and so on.
Raw material selection
In principle, corn stalks, potato vines, peanut vines, and grass can all be used for fermentation. However, it is worth noting that: Forage and other crops have very different nutritional values ​​due to different growth stages. General grasses should be harvested at the heading stage, and legumes should be harvested at the bud stage. In addition, raw silage with higher sugar content should be selected. To make the lactic acid bacteria breed rapidly, it is generally required that the silage material has a sugar content of about 1% to 5% in order to facilitate the formation of a good silage environment. The legume grass has more protein and less sugar, and it is best dried in the sun for storage. Silage should be mixed with other green feeds with high sugar content to achieve good results.
Fermentation steps and ideas
1. Shred or cut the silage material into small pieces. If there are two or more materials, mix them first.
2, adjust the moisture content of silage raw materials, the general optimum moisture content of 65% -75%, this time the most conducive to fermentation, while reducing the loss of dry matter. The judgment method is: grab a handful of material, hold it tight for one minute and release it. If the juice can be squeezed out, the moisture content is more than 75%. If it keeps its shape without water, it is 70%-75%. The grass ball has Elasticity and slowly loosening, it is 55-65%; grass ball immediately released, it is 55%; if pasture is broken, it is less than 50%.
3. Spray the starter according to the ratio of one ton of material to one kilogram Fuld Bio Starter. First use a 500-fold dilution of the Fuld BioFertilizer to spray the washed containers, then chop the ingredients, and fill them with a 10 cm high spray of the Fuld Biofermenter Diluent until it is full, then prudent. In particular, we must keep a solid edge, and finally spray more Fuld Biofermentation Diluent on the material surface, cover with a plastic film, sealed and fermented for about a month until the silage fermentation mature and aromatic or pickled cabbage flavor can be enabled. If the surface layer is black or has rancid odor, the surface layer should be discarded, and then from top to bottom, layer by layer, and timely after use. Moderate moisture content is an important condition affecting the quality of silage, pay attention to the convergence of moisture between the layers, no clip layer.
4, feeding silage, should not be more than the initial period, livestock and poultry have to adapt to the time, can be mixed with a portion of fine feed or compound feed, gradually increase the amount of livestock after adaptation. Females should not be fed more during late pregnancy.
Bleach Clean-up Enzyme is developed to remove residual hydrogen peroxide.Usually the cotton fabric bleached with hydrogen peroxide, the bleaching chemicals must be removed before dyeing in order to avoid the reaction between the bleaching agent and the dye. The traditional way to remove bleach is to rinse the fabric several times with water. Alternatively, you can use a mild reducing agent to clean the bleach. In addition, a large amount of water is needed in rinsing which wash out a large amount of wastewater.
Conzyme CAT200 is an extremely high concentrated liquid catalase preparation. It is specially developed to remove residual hydrogen peroxide and improve the last preparation prior to dyeing; it can largely reduce hazardous chemicals usage and save water.
Benefits:
Complete removal of residual H2O2 in preparation for dyeingWide pH range, convenient in using
No damage of fabric
Reduce processing time
Reduce water consumption and effluent volume
Environmental-friendly & bio-degradation
Enzyme preparations belong to protein, which may induce sensitization and cause anaphylaxis in sensitized individuals. Long-term exposure may cause minor irritation for skin, eyes or nasal mucosa, so any direct contiguity with human body should be avoided. If irritation or allergic response for skin or eyes develops, consult a doctor.
Bleach Clean-Up Enzymes,Catalase Enzyme,Enzyme For Peroxide Clean Up,Bleach Inhibitor
Sunson Industry Group Co., Ltd , https://www.sunsonchinaenzymes.com